Description: Euro MotoElectrics . . . Your Global Source for BMW Motorcycle Parts ! ! ! Part #: EDL3-105 The updated complete alternator replaces ALL the components of the Alternator and the rotor removal tool. The high output design includes a European made stator and rotor with increased electrical output and paired with a modern diode board, and adjustable voltage regulator. The system replaces the under performing Bosch charging system with a 105mm outside diameter stator (timing cover side) used on early BMW Airhead's from 1970-1976. This EDL3 charging system will reach charging voltage sooner than any other BOSCH style charging system we offer. Vehicle Manufacturer: BMWApplication: BMW Airhead 2 Valve, Moto Guzzi with Bosch-style Charging SystemMake/Model: BMW Airhead 2 Valve, Slash /5, /6 & R90SModel Years: Slash /6 & R90SManufacturer #:BMW Rotor: 12 31 1 244 642 (240 watt / 17A ) , 12 31 8 002 347 ( 180 watt / 13 A )BMW Stator: 12 31 1 243 001BMW Diode Board: 12 31 1 244 062, 063BMW Voltage Regulator: 12 32 1 244 409Bosch Rotor: 0 124 033 027Bosch Stator: Fits Frame Label # 0 120 340 001, 0 120 340 002, 0 120 340 003, 0 120 340 006Bosch Diode Board: 0 197 002 001, 0 197 002 002, 0 197 002 003Bosch Voltage Regulator: 12 32 1 244 409Moto Guzzi Rotor: 17712457Moto Guzzi Voltage Regulator: 29.70.38.01Power Rating: 400 Watts / 28 Amp Use the fitment table on the APPLICATION TABLE TAB BELOW to identify the correct kit size before ordering. You can measure the inside (timing cover side) and outside (stator frame side) diameter of your stator ring with calipers or use the BOSCH Alternator part number. Further instructions are included in the installation guide to verify the correct kit required. Some customers report increased component failure when using LITHIUM Style batteries. These batteries are not recommended nor supported for warranty replacement of components. Conventional wet acid or sealed AGM (Absorbed Glass Mat) batteries are known to work well with all conventional charging systems. See our LITHIUM specific alternator EDL4Li for this alternative. Review the Installation Guide, HERE. See article in HOW-TO section of Motorcycle Classics Magazine detailing the installation on a BMW /5 Airhead, HERE. Brand: EnDuraLast Some customers report increased component failure with the use of ODYSSEY and/or LITHIUM IRON batteries. These batteries are not recommended or supported for warranty replacement of components. Conventional wet lead acid or fel, sealed AGM (Absorbed Glass Mat) batteries are known to work well with all conventional charging systems. Alternator RotorDesigned to replace the original Bosch Rotor with modern EnDuraLast technologyOEM Iron Claw Poles, ETP Copper Wire, Nylon bobbin, double resin coating for insulation protectionComputer balanced for reduced high engine RPM vibration reductionSpecial resin soaking of coil increases life expectancy at high operating temperatures and engine RPM speedEuropean made of premium componentsAlternator StatorTiming Cover Side OD: 105 mmStator Frame OD: 107.5 mmInside Diameter: 74 mmEuropean made of premium components and precision machined in USA.Alternator Stator FrameNew cast with precision machining.Exact replica of original alternator cover and interchangeable.New clean terminals.New brush holder and brushes.Diode Board / RectifierReplaces original design with modern technology.52 heat sink fins, more surface area = increased heat dissipation.Connections use high temperature solder.Adjustable Voltage Regulator - 14.3 VoltsCan be adjusted to higher voltage, with voltage regulation adjustment guide.Set at 14.3 Volt trim setting; Adjustable voltage setting allow for optimizing the correct voltage for lower RPM urban operation.Must be used with caution as over charging with higher voltage setting can and will damage a battery.Metal housing with potted electrical components.Direct fitment from stock.Tools and FastenersIncludes specialized tool for removing the original alternator rotor.Includes all appropriate mechanical fasteners for a fresh clean and complete installation.Includes all electrical wires to connect the Diode Board / Rectifier to the Stator Frame.Includes new oil seal for behind the rotor. Fitment Table to determine the correct size. Bosch Alternator # EME Kit & Stator Size 0 120 340 001 EME # Ending 105-2Y Slash /5's only 0 120 340 002 EME # Ending 105 Slash /6 & R90S 0 120 340 003 EME # Ending 105 Slash /6 & R90S 0 120 340 004 EME # Ending 107 Slash /7 and later 0 120 340 005 EME # Ending 107 Slash /7 and later 0 120 340 006 EME # Ending 105 Slash /6 & R90S 0 120 340 008 EME # Ending 107 Slash /7 and later All Moto Guzzi EME # Ending 105 All Guzzi's There may be some cross-over on BMW applications BMW Slash /5 only EME # Ending 105-2Y BMW Slash /6 & R90S EME # Ending 105 BMW Slash /7 and later EME # Ending 107 Moto Guzzi All Years EME # Ending 105 Actual Stator Size if Measured EME # ending in: Alternator Cover Timing Cover 105-2 & 105-2y 105 mm 105 mm 105 105 mm 107.5 mm 107 107 mm 107.5 mm Part # EDL3-ALTKIT105 Model Year R60/6 (2476) 07/73-06/76 ECE R60/6 (2476) 01/74-05/76 USA R75/6 (2476) 09/73-06/76 ECE R75/6 (2476) 01/74-06/76 USA R90/6 (2476) 09/73-06/76 ECE R90/6 (2476) 01/74-06/76 USA R90S (2476) 09/73-06/76 ECE R90S (2476) 01/74-06/76 USA Thank you for shopping with Euro MotoElectrics. Your complete satisfaction is our goal. Please contact us if you are not completely satisfied with your purchase, prior to leaving feedback. We will make every effort to ensure complete satisfaction. We appreciate your business. TEAM EME~ Returns: All returns must be in original packaging where applicable and must NOT have been installed. Previously installed parts are NOT returnable. Returns must be in re-sellable condition. Please contact us if you are having problems with any item you have purchased from us. Visit My eBay Store: euro_motoelectrics
Price: 467.5 USD
Location: Denver, Colorado
End Time: 2023-12-15T19:05:52.000Z
Shipping Cost: 10.25 USD
Product Images
Item Specifics
Return shipping will be paid by: Buyer
Returns Accepted: Returns Accepted
Item must be returned within: 30 Days
Refund will be given as: Money back or replacement (buyer's choice)
Return policy details:
Country/Region of Manufacture: Italy
Custom Bundle: Yes
Surface Finish: New
Manufacturer Part Number: EDL3-105
Brand: EnDuraLast
Warranty: 1 Year
Bundle Description: This kit comes complete with rotor, stator, adjustable voltage regulator, heavy duty diode board and new harness, rotor brushes, die gel for the diode board and instruction manual.
